Body and Trim

Source: Chevrolet Dealer Service Bulletin Number: 01-08-67-003 Subject: Squeak From Rear of Convertible Top (Replace Protector Assembly) Model Year: 1998-2001 Corvette Condition Some customers may comment on a squeak coming from the... Read More

If you raise the rear portion of the canvas top, you will see the strut rods on each side which can be adjusted. Each rod has a 13mm adjusting nut and a 15mm locking nut. Loosen this locking nut and slightly turn the adjusting nut a little at a time.... Read More

The latch spring should be able to lift the trunk door enough to slide your fingers inside and open it the rest of the way. If this does not happen, check to see if the spring inside the latch assembly is missing. If it's not missing, have a service... Read More

Subject: Left Fuel Tank to Underbody Contact/Rattle Noise (Install Foam Insulator Pad) Source: Chevrolet Service BulletinNumber: 99-06-04-052Models: 1999 Chevrolet CorvetteCondition: Some customers may comment on a rattle type noise that appears to... Read More

Number: 00-08-42-002 Subject: Left Headlamp Door Does Not Stay Closed (Shim Headlamp Door Motor/Actuator and Replace Insulators) Model Year: 2000 Chevrolet Corvette Condition Some customers may comment that the left front headlamp door... Read More

Description:This press release, released from GM on July 24, 1998 takes an in-depth look at the Corvette's sheet molded composite body structure.Excerpt:"The automotive consumer may not even be aware of GM's latest product innovation. But a new... Read More

Description:This technical article was published in Composites Technology, September/October 1999, and looks at the C5 fixed roof coupe body structure and discusses the manufacturing and engineering techniques used in developing the hardtop model... Read More

Corvette Converts Floor Panels, Wheelhousings From Glass To Chopped Carbon By Composites Technology Magazine Staff | December 2005 Since 1953, General Motor's Chevrolet Corvette has been a trendsetter in glass-reinforced automotive composites and has... Read More

Source: Chevrolet Dealer Service Bulletin Number: 01-08-58-001 Subject: Windnoise Around B-Pillar (Add Sealer) Model Year: 1999-2001 Corvette Hardtop Condition Some owners may comment on windnoise around the B-pillar. Cause The... Read More

Subject: Deck Lid Not Flush With Left Hand Quarter Panel (Install Struts, Replace Right Deck Lid Hinge)Source: Chevrolet Dealer Technical Service BulletinNumber:  #03-08-66-001 - (01/13/2003)Models: 2003 Chevrolet Corvette Convertible and Z06... Read More